Sakr, TamerAssaly, Mohamed K.AbdelRashid, Rania SOmar, Samia2019-12-182019-12-182017-102357-0547https://doi.org/https://aprh.journals.ekb.eg/article_4882_4723a9891d10fc1068cc166667c7ccdd.pdfObjective: Directly incorporating aqueous solutions into hard gelatin capsules (HGCs) without dispersing them in an oily medium is considered a challenge for most researchers and manufacturers. The aim of the study is to evaluate the effect of gamma radiation (ɣ-radiation) on the adaptation of HGCs for aqueous solution delivery. Methods: Empty HGC shells were exposed to four of ɣ-radiation doses (1, 3, 5, 10 kGy). Then, the physicochemical properties of irradiated capsules were evaluation and compared with those of non-irradiated capsules. Fourier-transform infrared spectroscopy (FT-IR), capsule hardness, and water incorporation tests were performed. In-vitro disintegration/dissolution behavior determined as (rupture time) in different dissolution media was evaluated. Results: The results showed direct proportionality between the ɣ-radiation dose and HGC crosslinking degree up to 3 kGy, while at doses >3 kGy, degradation rather than crosslinking occurred. The results were clearly demonstrated by FTIR as peptide linkages between gelatin molecules. All the ɣ-irradiated HGCs submitted to hardness test were completely deformed without rupture with increasing capsule deformation work (J) for γ-radiation doses up to 3 kGy; the deformation work declined at doses >3 kGy. The water incorporation study revealed that capsules exposed to 3 kGy could hold up to 100 ml of methylene blue solution without deformation or leakage for 45 minutes compared with non-irradiated HGCs, which showed a significantly lower tolerance of only 2 minutes (p<0.001). The crosslinking of HGCs had a minor significant effect on in-vitro rupture time, especially at gastric pH. Conclusion: The irradiation technique may be used not only for sterilizing HGCs but also for adapting HGCs for aqueous solutions delivery, as it showed a significant positive effect, which was optimal at a dose of 3 kGy. However, these results are not sufficient for scaled-up manufacturing; thus, further investigations are strongly recommended.en-USLiquid-filled capsulesHard gelatin capsulesGamma radiationCross linkingArticlehttps://doi.org/